5‑2 Proposed arrangement for operations 5‑2 Proposed arrangement for operations to prepare prescribed eggs or egg products

5‑2 Proposed arrangement for operations to prepare prescribed eggs or egg products

(1) This section applies in relation to a proposed arrangement for operations to prepare prescribed eggs or egg products at a registered establishment. General requirements (2) The proposed arrangement must record that the applicant for approval of the arrangement is committed: (a) to meeting the objects referred to in section 3 of the Act that are applicable to the operations and the prescribed eggs or egg products covered by the arrangement; and (b) to complying with the requirements of the Act in relation to those operations. (3) The proposed arrangement must cover each stage of the operations. (4) The proposed arrangement must record details of the following matters: (a) the applicant’s management practices; (b) the organisational structure of the applicant; (c) the resources to be provided to carry out the operations covered by the arrangement; (d) the personnel who are to carry out the operations and the training those personnel receive; (e) the system of controls to be implemented to ensure that the conditions prescribed by Divisions 2 to 8 of Part 2 of this Chapter will be complied with in relation to the operations covered by the arrangement; (f) any other system of controls to be implemented to ensure that there will be reasonable grounds for issuing: (i) an export permit for prescribed eggs or egg products covered by the arrangement; or (ii) a government certificate in relation to prescribed eggs or egg products covered by the arrangement. (5) The matters required to be recorded in the proposed arrangement by paragraphs (4)(a) to (d) must be appropriate to ensure compliance with the requirements of the Act and that importing country requirements in relation to the operations covered by the arrangement are met. (6) If compliance with the requirements of the Act (not including section 5‑7 of this instrument) will not be sufficient to ensure that all importing country requirements relating to the operations and the prescribed eggs or egg products covered by the proposed arrangement will be met, the arrangement must: (a) identify each importing country requirement that will not be met; and (b) record details of the system of controls to be implemented to ensure that each importing country requirement referred to in paragraph (a) will be met.

Note: It is a condition of an approved arrangement for export operations in relation to prescribed eggs or egg products that all importing country requirements relating to export operations carried out in relation to the eggs or egg products in accordance with the arrangement, and the eggs or egg products, are met (see section 5‑7).

Requirement for HACCP plan (7) The proposed arrangement must provide for the implementation of an HACCP plan for each stage of the operations to prepare the prescribed eggs or egg products for export. (8) The HACCP plan must: (a) for each stage of the operations—identify the potential hazards that may reasonably be expected to occur; and (b) identify the means of control for each potential hazard; and (c) for each significant hazard that is identified—identify: (i) the critical control points; and (ii) the critical limits; and (iii) the procedures to be used to monitor the hazard to ensure compliance with each critical limit, including the frequency with which the procedures are to be carried out and the persons, or class of persons, who are to carry out the procedures; and (iv) the corrective action to be taken if a critical limit is exceeded, including action to address the exceeding of the critical limit and action to ensure it does not happen again; and (v) the procedures to be used to assess the effectiveness of action referred to in subparagraph (iv); and (d) identify procedures to be used to verify compliance with the HACCP plan and the frequency with which the procedures are to be carried out; and (e) provide for records to be made and documents to be kept to demonstrate compliance with the HACCP plan and its effectiveness.